Product ID:W-142-NCN WHITE NPG GEL COTE, UN1866
MSDS Date:02/22/1990
FSC:8010
NIIN:01-202-1220
MSDS Number: BLDCX

INTERPLASTIC CORPORATION

2015 BROADWAY NE
MINNEAPOLIS, MN 55413
US

Emergency Phone: 800-424-9300(CHEMTREC)

Info Phone: 612-331-6850

Cage: 16881

INTERPLASTIC CORP

MINNEAPOLIS, MN 55413 US

Telephone: 612-331-6850

Cage: 16881

STYRENE, MONOMER (SARA III)

CAS: 100-42-5

RTECS: WL3675000

Fraction By Weight: 35%

OSHA PEL 100 PPM

ACGIH TLV: S,50PPM/100STEL;9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

WARM, QUIET, AND GET MED ATTN.

RTECS: 9999999ZZ

UNTIL CLEAN-UP HAS BEEN COMPLETED. STOP SPILL @

RTECS: 9999999ZZ

TO SALVAGE TANK. REMAINING LIUQ MAY TAKEN UP ON

RTECS: 9999999ZZ

INTO CONTAINERS.

RTECS: 9999999ZZ

OF IN ACCORDANCE WITH LOCAL, STATE AND

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:NO Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:YES OSHA:NO
Health Hazards Acute and Chronic:EYE:CAN CAUSE SEV
IRRIT/RED/TEAR/BLURRED VISION. SKIN:PRLNG/RPTD CONT CAN CAUSE MOD
IRRIT/DEFAT/DERM/. INHAL:EXCESS INHAL OF VAP CAN CAUSE NASAL
IRRIT/DIZZ/WEAK/FATG, NAUS, HDCH, POSS UNCON. INGEST:CA N CAUSE GI
IRRIT/NAUS/VOMIT/DIARR. ASPIR OF MATL INTO LUNGS CAN CAUSE CHEM
PNEUMIT.
Explanation of Carcinogenicity:STYRENE:IARC CLASS 2B.
Effects of Overexposure:SEE HEALTH HAZARDS.
Medical Cond Aggravated by Exposure:LIVER ABNORMALITIES, KIDNEY DAMAGE,
AND LUNG DAMAGE.

First Aid:SKIN:THORO WASH EXPOS AREA W/SOAP/H2O. REMOVE CONTAMD CLTHG.
LAUNDER CONTAMD CLTHG BEFORE RE-USE. EYES:FLUSH W/LG AMT OF H2O.
LIFTING LIDS OCCAS. GET MED ATTN. INGEST: DO NOT INDUCE VOMIT. KEEP
PERSON WARM/QUIET & GET MED ATTN. ASPIR OF MATL INTO LUNGS DUE TO
VOMIT CAN CAUSE CHEM PNEUMIT WHICH CAN BE FATAL. INHAL:IF AFFECTED,
REMOVE TO FRESH AIR. IF BRTHG IS DFCLT, ADMINISTER O2. IF(SUPP
DATA)

Flash Point:88.0F,31.1C
Lower Limits:1.1%
Upper Limits:6.1%
Extinguishing Media:REGULAR FOAM OR CARBON DIOXIDE OR DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
H2O/FOAM MAY CAUSE FROTHING WHICH CAN BE VIOLENT & POSS ENDANGER
LIFE OF FIREFIGHTER, ESPEC IF (SUPDAT)
Unusual Fire/Explosion Hazard:VAP ARE >AIR & MAY TRAVEL ALONG GROUND OR
MAY BE MOVED BY VENT & IGNITED BY PILOT LIGHTS, OTHER
FLAMES/SPARKS/ HEATERS/SMOKING, ELEC MOTORS, STATIC (SUPP DATA)

Spill Release Procedures:SM SPILL:ABSORB LIQ ON PAPER, VERMICULITE,
FLOOR ABSORB, OR OTHER ABSORB MATL & TRANSFER TO HOOD. LG
SPILL:ELIM ALL IGNIT SOURCES(FLARES/FLAMES INCL LIGHTS, ELEC
SPARKS). PERSONS NOT WEARING PROT EQUI P SHOULD BE EXCLUDED FROM
AREA OF SPILL(ING 3)
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:CONTR OF MATL MAY BE HAZ WHEN EMPTIED.
SINCE EMPTIED CONTR RETAIN PROD RESIDUE(VAP/LIQ/SOLID), ALL HAZ
PREC GIVEN IN THIS DATA SHEET MUST BE OBSERVED.
Other Precautions:NONE SPECIFIED BY MANUFACTURER. SUBJECT TO SARA TITLE
III, SEC 313 & 40 CFR 372.

Respiratory Protection:IF TLV OF PROD OR ANY COMPONENT IS EXCEEDED, A
NIOSH/MSHA APPROVED AIR SUPPLIED RESPIRATOR IS ADVISED IN ABSENCE
OF PROPER ENVIRONMENTAL CONTROL.
Ventilation:PROVIDE SUFFICIENT MECHANICAL(GENERAL/LOCAL EXHAUST)
VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:NEOPRENE, NITRILE RUBBER GLOVES.
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:NORMAL WORK CLOTHING COVERING ARMS AND LEGS.
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC:INTO CONTR OF HOT/BURNING LIQ. EXPLOS
HAZ:DISCHARGE/OTHER IGNIT SOURCES @ LOC DISTANT FROM MATL HNDLG PT.
NEVER USE WELD/CUT TORCH ON OR NEAR DRUM(EVEN EMTPY) BECAUSE
PROD(EVEN JUST RE SIDUE) CAN IGNITE EXPLOS. CNDTNS (STAB):OXIDIZING
AGENTS. FIRST AID PROC:HAS STOPPED, GIVE ARTF RESP. KEEP PERSON(ING
2)

HCC:F4
Boiling Pt:B.P. Text:293F,145C
Vapor Pres:4.3(20C)
Vapor Density:3.6
Spec Gravity:1.2167
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER.
Percent Volatiles by Volume:65.0

Stability Indicator/Materials to Avoid:NO
AVOID CONTACT WITH: STRONG ALKALIES, STRONG MINERAL ACIDS AND OXIDIZING
AGENTS.
Stability Condition to Avoid:EXPOS TO EXCESSIVE HEAT/OPEN FLAME;STOR IN
OPEN CONTR; PRLNG STOR(6MTHS), STOR ABOVE 38C(100F). CONTAM W/(SUPP
DATA)
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE, LOW
MOLECULAR WEIGHT HYDROCARBONS, ORGANIC ACIDS.
Conditions to Avoid Polymerization:SEE CONDITION TO AVOID(STAB).

Waste Disposal Methods:SM SPILL:ALLOW VOLAT PORTION TO EVAP IN HOOD.
ALLOW SUFFICIENT TIME FOR VAP TO COMPLETELY CLEAR HOOD DUCT WORK.
DISPOSE OF REMAINING MATL I/A/W APPLIC REGS. LG SPILL:DESTROY BY
LIQ INCIN I/A/W APPLIC REGS. CONTAMD ABSORB SHOULD BE DISPOSED(ING
6)

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.